 |
|
|
|
            |
|
||||
|
||||
|
||||
11-20-2005, 08:02 AM
|
|||
|
|||
|
Is there a TSB for blinking dash lights?
My problem seems to be getting more persistant everyday! I was wondering if Ford or Roush has a TSB or fix available.
__________________
2005 Roush 05-1947: SOLD!! JLTII, Brenspeed tuned XCAL2, 4.10's, Bassani Catted X, Roush Lowering Springs, Steeda UDP's, Steeda Cowl Hood, CDC Sequentials, Midwest Auto Inserts 
|
|
11-20-2005, 08:58 AM
|
||||
|
||||
|
Automotive Recall and Technical Service Bulletin Titles for 2005 Ford Mustang V8-4.6L SOHC VIN H.
Service Bulletins TSB Number & Issue Date TSB Title 05-14-4 JUL 05 Engine Controls - MIL ON/DTC's P2106 and P2135 Set 05-10-19 MAY 05 Audio System - CD Player Skips/Locks-Up/Inoperative 05-9-18 MAY 05 Battery - Service/Charging Tips 05-9-14 MAY 05 Body - Convertible Top Raising/Lowering Instructions 05-9-3 MAY 05 Interior - Repair/Paint to Match Instructions 05-9-11 MAY 05 Steering/Suspension - Popping Noise When Turning 05-7-3 APR 05 Drivetrain - Drive Axle Whine 05-6-15 APR 05 Instruments - Air Bag Lamp ON/DTC B1891 or Code 53 05-3-1 FEB 05 Engine Controls - MAF Sensor Diagnostic Service Tip 04-26-16 DEC 04 Body - Weld Bonding Procedure 04-24-5 DEC 04 A/C/Audio - Defroster/Antenna Grid Diagnosis/Repair 04-24-20 DEC 04 Drivetrain - L/S Rear Axle Shudder/Chatter 04-24-14 DEC 04 Engine Controls - General PCM Programming Procedures 04-24-21 DEC 04 Restraint System - Seat Belts Slow to retract 04-24-3 DEC 04 Steering - Leather Coming Loose From Steering Wheel 04-16-1 AUG 04 Ignition System - Engine Misfire Diagnostics Tips 04-14-7 JUL 04 Electrical - Wiring Harness Replacement Guidelines/Tips
__________________
2001 Mustang GT Current Modificaitons Somewhere in between a Steeda Stage 1 and 2 2002 Ford Sport-Trac My Urban assualt vehicle
|
|
12-01-2005, 04:59 AM
|
||||
|
||||
|
I had the same problem for MONTHS. I took it to the dealer four times before I got the fix. I finally had to go to a different dealer, and let me tell you they have my loyalty. Not only did they fix it right, they treated my like a real person and not some dumb rube who doesn't know dic* about cars. Take it to a dealer with a good electrical guy, and tell him to call Roush. There is a voltage filter that should be installed on the back of the cluster. The way it was explained to me is: the cluster is recognizing ANY voltage spike as someone cranking the dimmer knob to full blast. The filter will maintain a constant voltage at all times. The fix works, trust me. I have been ranting and raving about this for months, and I am so glad it's fixed I bought the technician a case of beer. Make sure you tell the dealer to call Roush and BE PERSISTENT until they get a hold of the person who knows the issue. Roush knows it is a problem, and the fix is simple. The problem is (a) getting a technician who gives a crap enough to actually chase down an electrical problem and (b) getting a hold of a person at Roush who knows the problem. If you are in Texas anywhere near Houston, take it to Mac Haik Ford on I-10 and ask for Alex. He knows the fix. Even though they aren't "technically" a Roush dealer, they were still willing to do the Roush warranty work. I was in there every day and they showed me step by step what they did. I would highly recommend this service dept to anyone. I hate to say this, but I think that since this is a Saleen dealer, they know and respect people with a stiffy for their cars. They treated my baby like gold. She had her own bay inside the shop and never went outside.
|
|
12-01-2005, 07:58 AM
|
|||
|
|||
|
actually, I spoke to a warranty tech at roush and they said that it is the inverter on the back of the cluster. I now have zero dash lights as of last night!! He said they have to remove my cluster, send it to the manufacturer of the dash, and then they will send it back. This doesn't exactly make me happy, as my car will be down until the dash is received!
Are you saying that basically all they have to do is install a filter on the back of the cluster? Please give me the number of the person you spoke to at Roush, because the guy I spoke with said that this is the first he heard of this problem.
__________________
2005 Roush 05-1947: SOLD!! JLTII, Brenspeed tuned XCAL2, 4.10's, Bassani Catted X, Roush Lowering Springs, Steeda UDP's, Steeda Cowl Hood, CDC Sequentials, Midwest Auto Inserts
|
|
12-01-2005, 11:32 AM
|
||||
|
||||
|
I had mine removed and sent to Roush and they "fixed" it. Don't waste your time. I will get in touch with the dealer when I get off work tonight and get you the contact information.
|
|
12-01-2005, 11:55 AM
|
||||
|
||||
|
Hey I'm in the same boat here my dash is doing it too.My dash goes out then I mess with the fog light switch and some times they come back on.I Flick the fog light switch on and off that is.Sounds like I'm gona have to take it in to the dealer
 .NEW BUGS ON NEW CARS DAMMM...
|
|
12-01-2005, 02:52 PM
|
||||
|
||||
|
Light Problem
What serial number do you all having the light problem have? Is it an early problem or something they all have just hasn't shown up on all of them yet? Also, at about what mileage did thisw start to show up? From your conversations with the ROUSH guys have they fixed the problem already? From the fix you all are describing the problem seems to be caused by a design flaw so we should eventually all develop the problem.
|
|
12-01-2005, 04:22 PM
|
||||
|
||||
|
05-0695 Early Stage 2,It started about 6000 miles since then its getting worse.
|
|
12-01-2005, 08:03 PM
|
|||
|
|||
|
05-1947, started from day one, now currently have no dash lights at all!!!
Red, I did the same with the switch and it worked for a while but recently that stopped working!
__________________
2005 Roush 05-1947: SOLD!! JLTII, Brenspeed tuned XCAL2, 4.10's, Bassani Catted X, Roush Lowering Springs, Steeda UDP's, Steeda Cowl Hood, CDC Sequentials, Midwest Auto Inserts
|
|
04-18-2007, 04:19 PM
|
||||
|
||||
|
Good luck getting this fixed! I even have had it happen with car not running, but lights on. If it won't do it while they are looking, they won't believe you.
Paul
__________________
 06 Torch Red Sport Vert, Performance KB2.6L ,Roush Rear Springs, Roush Short Throw, SOS Double Pod/Autometer Boost & Fuel Pressure, Raptor in Vent, J&M APB & LCAs Appearance Midwest Auto Strut Covers and Radiator Extensions 275/40-18F 295/45-18R Nitto 555
|
|
04-18-2007, 05:36 PM
|
|||
|
|||
|
Thx for bringing the problem up, will have to Ck mine, Never driven the car at night.
Don't even know how to turn the lgts on 
|
|
04-18-2007, 06:00 PM
|
||||
|
||||
|
It just happened to me for the first time last week. I turned on my lower fogs just as dusk was hitting and I noticed No Dash lights. Of course the next day I went out in the AM. to check it and all was fine. Just figured it was a passing Gremlin.
But it if gets worse with time im not playin this game... 
__________________
2006 Roush W/all options, Roush Supercharger, Pulley Upgrade, 4.10 Gears, Power House 411 Alum Drive Shaft, Carriage House Eng Drive Shaft Loop, CDC Sequential Turn Signals, Metco Upper and Lower Control Arms, Roush Off Road Exhaust, MRT H Pipe, MRT 3 Gauge Pod, MRT Hood Struts, Roush Strut Brace, Custom Int Mods, 3-D Carbon Eleanor Grill, MGW Short Throw Shifter, CAI, Custom Tune, Best Qtr 12.2
|
|
04-18-2007, 06:02 PM
|
||||
|
||||
|
Same Problem Here....Guess I have to get it fixed now!
__________________
 2008 Adrenalin 3-valve V8 .................(300hp/300tq) Mods: 22" Bullitt rims, %20 Tint, ROUSH exhaust Tip, Custom emblems, Steeda Bed-hook Plates Perf: Flowmaster 50SUV Muffler, Motoblu 4pc Pulley set, GMS Coilpacks, K&N Polished CAI Coming soon: Custom 1.25" Drop Springs, SCT Xcal3 (Custom Tune), Ported Throttle-Body
|
|
04-18-2007, 06:06 PM
|
||||
|
||||
|
Ohh I just noticed that this was a really old thread...
So what was the up-dates on this one??? What is the fix, the filter behind the dash? I think I might need to tend to this one sooner than later...
__________________
2006 Roush W/all options, Roush Supercharger, Pulley Upgrade, 4.10 Gears, Power House 411 Alum Drive Shaft, Carriage House Eng Drive Shaft Loop, CDC Sequential Turn Signals, Metco Upper and Lower Control Arms, Roush Off Road Exhaust, MRT H Pipe, MRT 3 Gauge Pod, MRT Hood Struts, Roush Strut Brace, Custom Int Mods, 3-D Carbon Eleanor Grill, MGW Short Throw Shifter, CAI, Custom Tune, Best Qtr 12.2
|
|
04-18-2007, 06:16 PM
|
||||
|
||||
|
Quote:
Got mine done a while back and all works fine now. 
__________________
|
|
04-18-2007, 06:54 PM
|
||||
|
||||
|
Quote:
__________________
2006 Roush W/all options, Roush Supercharger, Pulley Upgrade, 4.10 Gears, Power House 411 Alum Drive Shaft, Carriage House Eng Drive Shaft Loop, CDC Sequential Turn Signals, Metco Upper and Lower Control Arms, Roush Off Road Exhaust, MRT H Pipe, MRT 3 Gauge Pod, MRT Hood Struts, Roush Strut Brace, Custom Int Mods, 3-D Carbon Eleanor Grill, MGW Short Throw Shifter, CAI, Custom Tune, Best Qtr 12.2
|
 |
| Thread Tools | |
| Display Modes | Rate This Thread |
|
|
Linear Mode
